凈化鋁材配件-丁腈手套硅油的清洗方法
- 發布人：
- 發布日期：2017-04-13 17:51:40
隨著潔凈室的誕生，手套就在潔凈服裝系統中扮演著一個重要角色，它不但應有充分的防護作用，而且不應向受控環境擴散微粒。以前人們往往將手套使用一次就扔掉，這樣不但成本高，而且也不利于環保。現在越來越多的工廠趨向于使用再生手套，就是將使用過的手套送交專業清洗公司進行潔凈清洗后再次使用。由于丁腈手套有優良的潔凈性能、防靜電性能和機械性能，特別適合再生清洗。
With the birth of the clean room, the gloves are playing an important role in the clean clothing system, which not only should have full protective effect, but also should not be controlled by the environment. In the past, people used to throw away the gloves once, so that not only high cost, but also not conducive to environmental protection. Now more and more factories tend to use recycled gloves, which will be used in the use of gloves to professional cleaning company for the use of clean. The nitrile gloves clean performance, excellent antistatic properties and mechanical properties, especially suitable for cleaning and regeneration.
但是，在手套的再生清洗中，一般是采用非離子中性表面清洗劑進行清洗，離子及灰塵、污漬等污染物較易去除，而來自于人體本身及所使用的護膚品中的硅油卻不是那么容易去掉而成為一個非常棘手的問題。
However, the use of non ion neutral cleaning agent for cleaning, ion and dust, stains and other pollutants are more easily removed, and from the human body itself and the use of skin care products in the silicone oil is not so easy to remove and become a difficult problem.
一般來說，手套硅油產生的原因有如下幾個：
Generally speaking, there are several reasons for the production of silicone oil:
1）季節差異造成：春夏季節，手套硅油問題幾乎不存在，因為天氣溫暖濕潤，人 們不需要涂抹護膚品也能使皮膚保持濕潤、光澤、有彈性；而秋冬季節，氣候干燥寒冷、愛美的姑娘們往臉上、嘴上、手上搽上臉霜、唇膏和手霜，防止皮膚干燥開裂，手套硅油問題就日益突出。
1) seasonal differences in the summer season, the problem is almost non-existent, because the weather is warm and humid, people do not need to apply skin care products can also make the skin moist, shiny, elastic; autumn and winter season, the climate is dry cold, beauty girls face, mouth, hand on the face cream, lipstick and hand cream to prevent dry skin cracking, gloves, silicone oil is increasingly prominent.
2）工序操作中產生：有些工序機臺含有硅油制劑，操作時人員手套接觸而污染。
2) operation of the process: some of the process machine contains silicone oil preparation, the operation of personnel gloves contact and pollution.
3）材質本身含有硅油：由于材質本身缺陷造成。
3) the material itself contains silicone oil: due to the material itself defects caused.
上述兩項產生的硅油，可通過正確清洗除去，但第三項的硅油僅靠清洗是無法去除的。
The above two of the production of silicone oil, can be removed by proper cleaning, but third of the silicone oil can not be removed by cleaning.
如何在清洗中有效去除手套硅油？凈化鋁材配件 http://www.jnjkjh.com/ 小編建議從以下幾方面綜合考慮：
How to remove the gloves and silicone oil effectively in the wash? Purification of aluminum parts of the small series of suggestions from the following several aspects:
1）清洗溶劑：要選用專用去油的非離子中性表面清洗劑；
1) cleaning solvent: non ion neutral surface cleaning agent to use special oil;
2）溶劑配比濃度：合適的濃度可以使去硅油效果達到最佳；應根據具體溶劑而定。
2) the concentration of the solvent concentration: the suitable concentration can make the effect of the silicone oil to reach the best.
3）溶劑清洗溫度：合適的溫度可使溶劑發揮最大清潔效能；以45-50℃為宜。
3) solvent cleaning temperature: the suitable temperature can make the solvent play the maximum cleaning efficiency; the 45-50 is appropriate.
4）溶劑清洗時間：時間不宜過短，否則溶劑不能與硅油很好地親合而影響清洗效果。一般至少要30分鐘。
4) solvent cleaning time: time is not too short, otherwise the solvent can not be very good with silicone oil and the effect of cleaning. At least 30 minutes.
5）漂洗水質：建議用RO/DI水，防止交叉污染。特別是最后幾道漂洗工序，一定要用DI水，否則清潔度無法保證。
5) rinse water quality: it is recommended to use RO/DI water to prevent cross contamination. Especially in the last several rinsing process, be sure to use DI water, or clean degree can not guarantee.
6）漂洗溫度：一定的溫度能更好地使殘留硅油從手套表面上析出。
6) rinse temperature: a certain temperature can better make the residual oil from the glove surface precipitation.
7）漂洗時間/次數：每次漂洗時間5-10分鐘左右為宜，次數不少于5次。
7) rinse time / Number: 5-10 minutes per rinse is appropriate, the number is not less than 5 times.
8）烘干機清潔：每次烘干手套前，應用無塵布沾溶劑擦拭烘干機內壁，以免交叉污染。
8) drying machine cleaning: every time before drying gloves, application of dust cloth with solvent wipe the inner wall of the dryer, so as to avoid cross contamination.
總之，將手套硅油清洗干凈不是件容易的事，需要我們不斷地實驗、實驗、再實驗，才能找出一個最佳清洗方案。鑒于硅油清洗的難度如此之大，我們建議在使用手套時應采取一些預防措施以將硅油污染減至最少，如：潔凈室工作人員不允許化妝；進潔凈室之前，應將臉部及手部徹底清洗干凈；含硅油制劑不允許在潔凈室內使用等。
In short, it is not easy to clean the gloves and silicone oil, we need to continue to experiment, experiment, and then experiment, to find out a best cleaning solution. In view of the difficulty of silicone oil cleaning is so large, we recommend that before in gloves should take some preventive measures to silicone oil pollution to a minimum, such as: clean room staff not allowed to make-up; into the cleanroom, should be the face and hands are thoroughly cleaned; containing silicone oil formulation does not allow for in clean indoor use.
